Clymer Kawasaki Jet Ski 1976-1991
Clymer Kawasaki Jet Ski 1976-1991

Kawasaki Jet Ski, 1976-1991
Part #: W801

608 pages

CHAPTER ONE / GENERAL INFORMATION

CHAPTER TWO / TROUBLESHOOTING

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Operational checklist / Lubrication / Fuel selection / Break in procedure / Recommended fuel mixture / Fuel mixing / Starter gear oil / Control cable lubrication / Periodic maintenance / Fuel vent check valve inspection / Oil tank vent valve / fuel filter / Flame arrester / Impeller / Rubber coupler / On-shore cooling / Steering cable adjustment / Trim cable adjustment / Throttle cable adjustment / Choke cable adjustment / Engine tune-up / Storage / Specifications

CHAPTER FOUR / ENGINE (300 CC)
Engine lubrication / Service precautions / Serial numbers / Servicing engine in hull / Engine / Engine top end / Cylinder / Piston, wrist pin and piston rings / Intake manifold and reed valve / Crankcase and crankshaft / Starter clutch / Specifications

CHAPTER FIVE / ENGINE (400 CC, 440 CC AND 550 CC)
Engine lubrication / Service precautions / Serial numbers / Servicing engine in hull / Engine / Engine top end / Cylinder / Piston, wrist pin and piston rings / Crankcase and crankshaft / Specifications

CHAPTER SIX / ENGINE (650 CC)
Engine lubrication / Service precautions / Serial numbers / Servicing engine in hull / Engine / Engine top end / Cylinder / Piston, wrist pin and piston rings / Reed valve assembly / Crankcase and crankshaft / Water drain valve / Starter reduction gear / Specifications

CHAPTER SEVEN / DRIVE TRAIN
Drive shaft / Jet pump / Reverse system / Specifications

CHAPTER EIGHT / FUEL AND EXHAUST SYSTEMS
Flame arrester / Mikuni carburetor / Keihin carburetor / Fuel pump / Fuel tank / Fuel tap / RPM limiter / Exhaust system / Exhaust system cleaning and inspection / Specifications

CHAPTER NINE / ELECTRICAL SYSTEM
Battery / Charging system / Electrical starting system / Capacitor discharge ignition CDI / Electric box / Specifications

CHAPTER TEN / OIL INJECTION SYSTEM
Oil pump service / Oil tank / Oil level gauge / Oil tank vent check valve / Oil pump / Specifications

CHAPTER ELEVEN / BILGE SYSTEM
Vacuum-type bilge system / Electric-type bilge system / Specifications

CHAPTER TWELVE / STEERING AND HULL REPAIR
Steering assembly / Hull repair / Deck frame / Specifications

INDEX

WIRING DIAGRAMS

Models covered:
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JB650 Jet Mate
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JF650TS
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JL650SC
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JS300
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JS300SX
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JS400
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JS440
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JS440SX
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JS550
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JS550SX
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JS650SX
1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 KAWASAKI JS650X-2

Manufacturer Part Number: W801