Clymer Yamaha Four-Stroke Personal Watercraft 2002-2009
Clymer Yamaha 4 Stroke Personal Watercraft 2002-2009

Yamaha Four Stroke PWC 2002-2009*
Part #: W807

*Does not cover 1800 cc models.
Does not cover 2-stroke models.

288 pages

CHAPTER ONE / GENERAL INFORMATION

CHAPTER TWO / TROUBLESHOOTING
Engine operating requirements / Starting the engine / Fuel delivery / Ignition system / Electronic fuel injection EFI / Charging system / Warning system / Cooling system / Engine / Compression test

CHAPTER THREE / LUBRICATION , MAINTENANCE AND TUNE-UP
Inspection before each use / Fuel leak check / Water separator check / Battery inspection / Steering system check / Throttle control operation / Shift control operation check / Quick shift trim selector QSTS operation check / Drain plug check / Engine oil level / Lanyard switch operation / Water leak inspection / Inspection after each use / Cooling system flush / Cleaning / Periodic maintenance schedule / Engine oil change / Engine oil filter change / Air filter cleaning inspection / Spark plug plugs / Jet pump lubrication / bilge pump screen cleaning / Siphon pump screen cleaning / Water inlet filter cleaning inspection / Valve clearance adjustment and impeller clearance adjustment

CHAPTER FOUR / ENGINE
Removal installation / Oil tank / Oil pump / Reduction gear / Camshaft cover cam shaft / Cylinder head / Cylinder block / Oil pressure switch / Engine coolant temperature ECT sensor / Oil pan / Crankcase cover crank case / Piston / Connecting rod / Crankshaft crank shaft cylinder block inspection / Engine bearing selection / Anode / Engine break in

CHAPTER FIVE /DRIVE SYSTEM AND JET PUMP
Ride plate / Intake grate / Jet pump assembly / Impeller housing / Impeller / Stator / Stator bearing housing / Intermediate bearing housing / Steering nozzle / Trim nozzle and reverse bucket

CHAPTER SIX / FUEL SYSTEM
Air filter / Air filter housing / Throttle body / Fuel rail / Injector injectors / Fuel pump / Fuel pump module / Throttle position sensor TPS / Throttle cable / Idle speed and synchronization

CHAPTER SEVEN / EXHAUST AND COOLING SYSTEM
Exhaust pipe / Exhaust outlet / Water tank / Exhaust hose / Water lock / Exhaust tube / Exhaust overheat switch / Exhaust manifold / Cooling system / Thermostat / Thermostat housing / Water pressure relief valve and housing and water inlet filter

CHAPTER EIGHT / ELECTRICAL SYSTEM
Battery / Battery cables / Starter / Flywheel fly wheel / Battery charge coil / Pulser coil coils / Ignition coil coils / Engine control unit ECU brain / Main relay / Fuel pump relay / Starter relay / Electronic throttle control relay / Voltage regulator rectifier / Tilt detection switch and color wiring diagrams

CHAPTER NINE / BILGE SYSTEM
Operation / Bilge pump / Jet siphon pump and indicator siphon break fitting

CHAPTER TEN / STEERING, HELM AND CONTROLS
Handlebar handle bar bars cover / Throttle cable / Throttle control / Quick Shift Trim Selector DSTS / Start - stop and lanyard switch / Steering cable / Steering helm / Steering switch / Steering sensor / Shift cable / Shift lever / Air temperature sensor / Compass assembly

COLOR WIRING DIAGRAM

Models covered:
2005 2006 2007 2008 FX
2005 2006 2007 2008 FX Cruiser
2005 2006 2007 2008 FX Cruiser High Output
2005 2006 2007 2008 FX High Output
2002 2003 2004 FX140
2002 2003 2004 FX140 Cruiser
2005 2006 2007 2008 2009 VX
2005 2006 2007 2008 2009 VX Cruiser
2005 2006 2007 2008 2009 VX Deluxe
2005 2006 2007 2008 2009 VX Sport

Manufacturer Part Number: W807